Exclusionary recovery of phosphate anions with low concentration from wastewater using a CoNi-layered double hydroxide/graphene electronically controlled separation film
Exclusionary recovery of phosphate anions with low concentration from wastewater using a CoNi-layered double hydroxide/graphene electronically controlled separation film
刘堰 1过嘉鑫 2杨颂 3徐世娴 2杨言言 2余钟亮 2郝晓刚3
扫码查看
点击上方二维码区域，可以放大扫码查看
作者信息
1. 太原理工大学化学学院,太原 030024;上饶师范学院化学与环境科学学院,上饶 334001
2. 上饶师范学院化学与环境科学学院,上饶 334001
3. 太原理工大学化学工程与技术学院,太原 030024
折叠
摘要
采用滴涂结合电化学沉积两步法制备了一种具有优良电活性的三维花状钴镍双金属氢氧化物/石墨烯(CoNi-LDH/G)杂化膜,用于电控离子交换过程(electrically switched ion exchange,ESIX)吸附水溶液中低浓度的磷酸根(PO43-)离子.结合X射线衍射(XRD)、X射线光电子能谱(XPS)、扫描电子显微镜(SEM)和透射电子显微镜(TEM)等对CoNi-LDH/G杂化膜进行形貌、组成及结构表征.采用电化学方法考察了该杂化膜在不同吸附电压、不同初始浓度、共存离子及不同pH值条件下对PO43-吸附性能的影响.实验结果表明:通过调节氧化还原电位,即使在低浓度下,杂化膜对PO4-也具有良好的吸附性能,且可以在较宽的pH值(4～10)范围内使用,同时受共存离子及其浓度变化影响甚小.此外,G对PO43-的吸附容量为1.10mg·g-1,CoNi-LDH对PO43-的吸附容量为11.74 mg·g-1,二者吸附容量之和小于CoNi-LDH/G对PO43-的吸附容量(16.25 mg·g-1).同时,结合O1s的XPS数据分析发现,CoNi-LDH/G杂化膜对PO43-的吸附过程除了层间阴离子交换、PO43-与层板金属离子配位的配体交换外,还存在G与CoNi-LDH之间的协同效应.
Abstract
A high electroactive hybrid film of CoNi-layered double hydroxide grown on graphene(CoNi-LDH/G)with a three-dimensional(3D)flower-like structure was successfully prepared by using two-step coating and electro-deposition method,and applied to separate and recover low concentrated phosphate anions from wastewater via elec-trically switched ion exchange.The morphology,composition,and structure of the CoNi-LDH/G hybrid film were demonstrated by X-ray diffraction(XRD),X-ray photoelectron spectroscopy(XPS),scanning electron microscopy(SEM),and transmission electron microscope(TEM).The effect of absorption potentials,initial phosphate concentra-tions,co-existing anions,and pH on the phosphate electrochemistry adsorption performance of the hybrid film was also investigated.The experimental results indicated that the hybrid film had a high adsorption performance by adjusting the redox potential,even at low concentrations.In addition,it can be used in a wide pH range(4-10),and its adsorption capacity for PO43-was little affected by coexisting ions and their variations in concentration.Further-more,the adsorption capacity of G and CoNi-LDH for PO43-was 1.10 and 11.74 mg·g-1,respectively.Moreover,the sum of these two was also lower than that of the CoNi-LDH/G hybrid film(16.25 mg·g-1).Combined with O1s XPS analysis,it was found that PO43-adsorption on CoNi-LDH/G hybrid film aside from interlayer ion exchange,com-plexation ligand exchange between PO43-and layer-plate metal ions,the synergistic effects between G and CoNi-LDH also existed.
关键词
钴镍双金属氢氧化物/石墨烯/电控离子交换/排异性/低浓度/磷酸根
Key words
CoNi-layered double hydroxide/graphene/electrically switched ion exchange/exclusionary/low concentration/phosphate anion
维普
万方数据